Product ID:YELLOW EPOXY POLYAMIDE MIL-P-23377F TYPE I, CLASS I, COMP A
MSDS Date:01/07/1993
FSC:8010
NIIN:01-106-8404
Kit Part:Y
MSDS Number: BVRFW

RANDOLPH PRODUCTS CO

92 N 12TH ST
CARLSTADT, NJ 07072
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

STRONTIUM CHROMATE (SARA III)

CAS: 7789-06-2

RTECS: GB3240000

Fraction By Weight: 20%

OSHA PEL C 0.1 MG (CRO3)/M3

ACGIH TLV: 0.0005MG(CR)/M3,A294

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

2-BUTOXYETHANOL (SARA III)

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 5-20%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9394

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 20%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL;9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPYLENE GLYCOL MONOMETHYL ETHER

CAS: 107-98-2

RTECS: UB7700000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9394

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 15%

OSHA PEL 200 PPM; Z-2

ACGIH TLV: S, 50 PPM; 9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NAPHTHA, LIGHT ALIPHATIC (PETROLEUM) (THIS MATERIAL

CAS: 64742-89-8

Fraction By Weight: 5%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5 - 10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:DRYING, CRACKING & IRRITATION OF THE
SKIN. CAN CAUSE RASH, SCALING OR BLISTERING. HIGH CONCENTRATIONS
MAY CAUSE HEADACHES, DIZZINESS, CNS EFFECTS, FAINTING AND IF
EXPOSURE CONTINUES MAY CAUSE DEATH.
Explanation of Carcinogenicity:STRONTIUM CHROMATE IS CONSIDERED KNOWN
OR SUSPECT HUMAN CARCINOGEN BY IARC, MAK, NIOSH, NTP AND ACGIH
Effects of Overexposure:THIS PRODUCT REACTS W/SKIN PROTEIN AND MOISTURE
& CAN CAUSE RASH, SCALING OR BLISTERING. HIGH CONCENTRATIONS MAY
CAUSE HEADACHES & DIZZINESS, ARE ANESTEHIC, AND MAY HAVE CENTRAL
NERVOUS SYSTEM EFFECT S, INCLUDING DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS
PRODUCT. CONTACT LENS WEARERS SHOULD CONSULT PROVIDER DEFORE
HANDLING- CONSULT PHYSICIAL IF ANY EYE CONTACT.

First Aid:INHALATION-REMOVE VICTIM TO FRESH AIR, RESTORE BREATHING,
CONSULT DOCTOR. SKIN-FLUSH W/WATER. EYE-IMMEDIATELY FLUSH W/WATER
FOR 15 MIN, CONSULT A DOCTOR. INGESTION-DO NOT INDUCE VOMITING.
KEEP PERSON WARM, QUIET AND GET MEDICAL ATTENTION. SMALL AMOUNTS
OF LIQUID ASPIRATED INTO THE RESPIRATORY SYSTEM DURING INGESTION,
OR VOMITING MAY CAUSE CHEMICAL PHEUMONIA OR PULMONARY EDEMA.

Flash Point Method:SCC
Flash Point:21.0F,-6.1C
Lower Limits:0.9%
Upper Limits:12.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE, DO NOT USE
WATER HOSE STREAM. FULL BUNKER GEAR IN FIRE AREA (HELMET W/FACE
SHIELD, BUNKER COAT, GLOVES, RUBBER BOOTS)
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR. BEWARE OF
FLASHBACK. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME
HEAT. WATER MAY BE USED TO COOL CLOSED CONTAINERS.

Spill Release Procedures:AVOID BREATHING VAPOR, INSURE ADEQUATE
VENTILATION. AVOID SOURCES OF IGNITION. ELIMINATE SOURCE OF SPILL
IF POSSIBLE W/OUT RISK OF INJURY. APPLY ABSORBENT MATERIAL (SAND,
VERMICULITE, DUST) TO SPILL. USE NON-SPARKING TOOLS, PPE, CLEAN
DRY RAGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL DRY AREA, AWAY FROM
INCOMPATIBLE MATERIALS (SEE SEC 5). GROUND DRUMS WHEN BEING
EMPTIED. AVOID CONTACT OR INHALATION OF VAPOR.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR FOR MATERIALS IN
SECTION 2 RECOMEMDED. PRECAUTIONS MUST BE TAKEN SO THAT PERSONS DO
NOT BREATH THE VAPORS OR HAVE CONTACT W/EYES & SKIN.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME AND PATTERN PROVIDED TO
KEEP AIR CONCENTRATIONS BELOW APPLICABLE EXPOSURE LIMITS
Protective Gloves:CHEMICAL RESISTANT GLOVES
Eye Protection:FACE SHIELD OR CHEM GOGGLES W/SIDESHIELD
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY. REMOVE PROTECTIVE CLOTHING AND WASH BEFORE REUSE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HMIS RATINGS: HEALTH-2, FLAMMABILITY-3, REACTIVITY-0 PERSONAL
PROTECTION-X. THIS IS PART A OF A TWO PART KIT, PLEASE REFER TO
PART B FOR ADDITIONAL INFORMATION.

Boiling Pt:B.P. Text:172F,78C
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:UNDER 25%
Appearance and Odor:THIN YELLOW LIQUID, TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:64.4%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND ALKALIES
Stability Condition to Avoid:HIGH TEMPERATURES AND INCOMPATIBLE
MATERIALS
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES CARBON
MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS. COORDINATE WITH
SUPPORTING INSTALLATION AND/OR MACOM ENVIRONMENTAL OFFICE PRIOR TO
DISPOSAL

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.